Wayne...
Wouldn't a MC that had been rebuilt w/ the seal accidentilly turned
backwards also cause crazy behavior with the piston (like you describe).
But then again, what do I know about brakes?
Paul
----- Original Message -----
From: "Wayne" <rengrave@verizon.net>
To: <triumphs@autox.team.net>
Sent: Saturday, September 12, 2009 6:59 PM
Subject: [TR] Brake master cylinder and bleeding the brakes.
>I think I need a new brake master cylinder, I rebuilt the old one but I was
> not happy with the
> bore surface finish after I honed it. The finish was not very smooth and
> when
> I assembled
> the plunger and new seals, I pushed the piston in and it would just sit
> there.
> I had to bang it on the work bench to send the piston back to the front of
> the
> bore.
> I had plenty of brake fluid in the bore when I assembled it but it still
> would
> not return
> to the front of the bore on it's own.
> I was hoping it would move once it was flooded with fluid on the car,
> but.........
>
> I managed to bleed the rear brakes with gravity, however the front brakes
> would not bleed,
> I tried pumping the pedal (which didn't feel right) and the fluid in the
> reservoir would not
> go down.
>
> I think the piston is stuck at the rear of the bore in the master cylinder
> and
> therefore is blocking
> the fluid from the reservoir to the piston and the pipes. When I push the
> pedal I'm not feeling
> resistance. it's not a smooth travel.
>
> I thought the PDWA could be blocking the fluid, but I think it lets fluid
> go
> by no matter where
> the shuttle is located inside it.
>
> So, I think it's time to order a new M/C.
> Any suggestions where I should go? TRF, Moss, BRNW or have mine rebuilt by
> a
> pro?
>
> Wayne
> 73 TR6
> _______________________________________________
>
> Support Team.Net http://www.team.net/donate.html
>
> This list supported in part by the Vintage Triumph Register
> http://www.vtr.org
>
>
> Triumphs@autox.team.net
> http://autox.team.net/mailman/listinfo/triumphs
>
>
> http://www.team.net/archive
_______________________________________________
Support Team.Net http://www.team.net/donate.html
This list supported in part by the Vintage Triumph Register
http://www.vtr.org
Triumphs@autox.team.net
http://autox.team.net/mailman/listinfo/triumphs
http://www.team.net/archive
|