Hey, KT. That's a real good start on your preflight/postflight lists.
Whenever you see Winston Cup cars in the garage they always have checklists
taped all over them.
Dale C.
/////////////////////////////////////////////////////
Subject: check lists
This is a very early edition of these checks and I am sure I will add more
detail or delete it as time goes on.... I just wanted something that fits
what we actually do.
K
Checklist's
1. Car Prep
2. Trailer Prep
3. Trailer loading
4. Pits Set up
5. Pre-race
6. Starting line
7. Shut down / data download
8. Between run Maintenance
Car Prep
1. Fuel
2. Wheel bearing's
3. Fluids
a. Rear end
b. Trans
c. Oil tank
d. Batteries
4.
5. Clutch adjusted
6. Valves adjusted
7. Tire Pressures
8. Spoiler angle
9. Fire extinguishers
10. Leaks and fitting's tight
Trailer Prep
1. Wheel bearings
2. Tire pressures
3. Grease ball and load levelers
4. Pack
5. Locks
Pack Trailer
1. MSD parts
2. Nitrous and Fuel Jets
3. Printer
4. Tool box
5. Brake cleaner
6. Hand cleaner
7. Shop towels
8. Trash bags
9. Tarp and stakes
10. Table
11. Nitrogen bottle
12. Generator
13. Air compressor
14. Nitrous Pump
15. Lines and fitting's for air tank and Nitrous
16. Spare trailer tire
17. Mini bike
18. Floor jack and Stands
19. Winch and extension cord
20. Canopy
21. Radio
22. Drill and bits
23. Coolers
24. Nitrous scale
25. Air tools
26. Regulator and lines
27. Tow Strap/ push bar
28. Fuel / Generator Gas
Pit set up
1. Tarp
2. Canopy
3. Cooler
4. Car out
5. Tie downs stored
6. Nitrous station set up
7. Generator
8. Air compressor
9. Air lines and tools
10. Car prepped for tech
a. drivers suit
b. log book
c. tow strap
CAR PREP
1. Tire Pressures
2. Lug nuts
3. Fire bottle pins
4. Parachute Packed
5. Valves adjusted
6. Fuel car
7. Carb Jets
8. Nitrous Jets
9. Fuel Pressures
10. Fuel line leaks
11. Pre-heat oil
12. Start
13. Check for oil and water leaks
Starting line
1. Carb cover removed
2. Nitrous bottles on
3. Nitrogen bottle pressure set
4. Parachute ready
5. Fire bottle safety pins removed
6. Driver prepared
7. Tach run set
8. EGT's cleared
9. Starting sequence
a. Power on
b. Started engaged
c. Oil pressure check
d. Ignition on
e. Running pressure and temp
f. Record run on tach
g. Nitrous valves on
h. Purge systems
i. Launch tach
j. Say hello to Cris and Ed
SHUT DOWN Procedures
1. load parachute
2. pin fire bottles
3. Tow back
4. Record data
a. Tach pass
b. EGT's
c. Jets
d. Timing
e. Nitrous jets and fuel pressure
BETWEEN RUN MAINTENANCE
1. Fuel car
2. Valves adjusted
3. Oil Filter check
4. Oil level
5. Float bowl level
6. Fuel Pressures
7. Nitrous jets
Nitrous systems checks
1. Fuel Pressure
2. Jets
3. Nitrogen Pressure
4. Nitrous level
Timing check.
Nitrous system on. Nitrous Bottle OFF Fuel Pump Fuse not installed
Hit Button. Check first and second stage timing. Check phasing on
Distributor
Fuel Pump Fuse installed Check for the motor to bog when running
Car not running Butterfly's open. Hit Nitrous button. With NO FUEL fuse.
Watch Nitrous come out.
Keith Turk
Austin Healey 100, Bugeye, Box sprites, Bonneville Camaro ( Land Speed
Racer)
----------------------------------------------------------------------------
The information transmitted is intended only for the person or entity to
which it is addressed and may contain confidential and/or privileged
material. Any review, retransmission, dissemination or other use of, or
taking of any action in reliance upon, this information by persons or
entities other than the intended recipient or employees of
MD Helicopters, Inc. is prohibited. If you received this in error, please
contact the sender by email and delete the material from any computer..
///
/// land-speed@autox.team.net mailing list
/// To unsubscribe send a plain text message to majordomo@autox.team.net
/// with nothing in it but
///
/// unsubscribe land-speed
///
///
|