Niels -
If the oil feed banjo bolt is loose, then excess oil will leak into the
rocker area. I'd check that first before assuming the worst. Also, was
your oil pressure showing high? If it's too high you'll get a similar
result.
On the rear axle, if you are getting any leakage around your hubs, check to
make sure the lug nuts are tight on the spline hub. If they aren't tight,
it will leak and your hub studs will wear out! If it's all set up
correctly with paper gasket and o-ring, then it should NOT leak if the hub
is tightly bolted per the manual spec.
Also, if recently rebuilt with rear crank seal, there's no where for excess
crankcase pressure to go, so it pushes oil out every possible spot it can -
especially on long trips. Suggest you install a PCV (easy to do) which
will help equalize the pressure in the crankcase, I think you will find
this is your problem.
If your motor was recently rebuilt, then the oil problem is related to the
rebuild and stuff not being properly sorted just yet. I'd be very
surprised if anything is actually wrong with the motor itself, it's just
not sorted properly, that's all.
Best,
Alan
On Sunday, July 27, 2014, Niels Bengaard <bengaard@850r.dk> wrote:
> Hi
>
>
>
> Just returned from a trip from Denmark to England in my BJ8. I will write a
> story about that later, it was great.
>
> There were no problems with the car except for large oil consumption and
> oil
> spillage.
>
>
>
> The undercarriage was covered in oil and the oil consumption was from max
> to
> min on the oil stick in 250 miles.
>
> I have an idea that it's the rocker assembly that's worn down, take a look
> at the videos.
>
> Also some leak from the rear axle, since there were oil under the rear
> seats
> and the rear exhaust system.
>
> What about the leak around the engine / gearbox?
>
> The engine is restored 10000 miles ago by previous owner, don't know the
> extent, except it should have been rebored with new pistons and Denis Welch
> oil pump. New type of seal on the crank and head made to lead free fuel.
>
>
>
>
> http://healey.850r.dk/albums/Picture%20Album/album/Oil%20Consumption%202014/
> index.html
>
>
>
> What is normal oil consumption?
>
>
>
> Hope you have some ideas
>
> Niels Bengaard, Denmark
> _______________________________________________
> Support Team.Net http://www.team.net/donate.html
> Suggested annual donation $12.75
> Archive: http://www.team.net/archive
> Forums: http://www.team.net/forums
>
> Healeys@autox.team.net <javascript:;>
> http://autox.team.net/mailman/listinfo/healeys
>
> Unsubscribe/Manage:
> http://autox.team.net/mailman/options/healeys/healey.nut@gmail.com
_______________________________________________
Archive: http://www.team.net/archive
Healeys@autox.team.net
http://autox.team.net/mailman/listinfo/healeys
|